Jeep Grand Cherokee

1993-1999 of release

Repair and car operation


Jeep Grand Cherokee
+ Cars of mark Jeep Grand Cherokee
- Options and routine maintenance
   - The schedule of routine maintenance Jeep Cherokee
      Introduction
      The general information on options
      Checks of levels of liquids (each 400 km (250 miles) run or weekly)
      Check of a condition of tyres and pressure in them (each 400 km (250 miles) run or weekly)
      Check of level of a liquid of automatic transmission (each 400 km (250 miles) run or weekly)
      Check of level of a liquid of system of hydrostrengthening of a wheel (each 4800 km (3000 miles) run or times in 3 months)
      Change of impellent oil and the oil filter (each 4800 km (3000 miles) run or times in 3 months)
      Check and battery service (each 4800 km (3000 miles) run or times in 3 months)
      Check of serviceability of system of cooling (each 4800 km (3000 miles) run or times in 3 months)
      Check of a condition and replacement of hoses passing under a cowl (each 4800 km (3000 miles) run or times in 3 months)
      Check of a condition and replacement of brushes of screen wipers (each 4800 km (3000 miles) run or times in 3 months)
      Check of a condition of a suspension bracket and steering
      Check of a condition of system of release of the fulfilled gases (each 12 000 km (7500 miles) run, or times in 6 months)
      Level check трансмиссионного oils of a manual transmission (РКПП) (each 12 000 km (7500 miles) run, or times in 6 months)
      Check of level of oil of a distributing box all-wheel drive (4WD) models (each 12 000 km (7500 miles) run, or times in 6 months)
      Check of level of oil of differential (each 12 000 km (7500 miles) run, or times in 6 months)
      Rotation of wheels (each 12 000 km (7500 miles) run, or times in 6 months)
      Check of a condition of brake mechanisms (each 12 000 km (7500 miles) run, or times in 6 months)
      Check of a condition of components of the power supply system (each 12 000 km (7500 miles) run, or times in 6 months)
      Condition check, adjustment of a tension and replacement drive a belt (each 12 000 km (7500 miles) run, or times in 6 months)
      Check of a condition of seat belts (each 12 000 km (7500 miles) run, or times in 6 months)
      Check of functioning of the gauge-switch of the permission of start (only models with АТ) (each 12 000 km (7500 miles) run, or times in 6 months)
      Chassis greasing (each 12 000 km (7500 miles) run, or times in 6 months)
      Replacement of the air filter (each 48 000 km (30 000 miles) run, or times in two years)
      Replacement of a liquid and the filter of automatic transmission (each 48 000 km (30 000 miles) run, or times in two years)
      Adjustment of tapes of automatic transmission (АТ) (models since 1994 вып.) (each 48 000 km (30 000 miles) run, or times in two years)
      Replacement трансмиссионного oils of a manual box (switching) of transfers (РКПП) (each 48 000 km (30 000 miles) run, or times in two years)
      Change of oil of a distributing box (model 4WD) (each 48 000 km (30 000 miles) run, or times in two years)
      Change of oil of differential (each 48 000 km (30 000 miles) run, or times in two years)
      Service of system of cooling (опорожнение, washing and refuelling) (each 48 000 km (30 000 miles) run, or times in two years)
      Check of a condition and replacement of the valve of system of operated ventilation картера (PCV) (engines V8) (each 48 000 km (30 000 miles) run, or times in two years)
      Check, procleaning and replacement of a hose of system of continuous ventilation картера (CCV) (6 cylinder engines) (each 48 000 km (30 000 miles) run, or times in two years)
      Check of serviceability of functioning of system of catching of steams of fuel (each 48 000 km (30 000 miles) run, or times in two years)
      Cleaning of the filter of ventilation картера (engines V8) (each 48 000 km (30 000 miles) run, or times in two years)
      Replacement of the fuel filter (each 48 000 km (30 000 miles) run, or times in two years)
      Replacement of spark plugs (each 48 000 km (30 000 miles) run, or times in two years)
      Check of a condition of candle wires, covers and бегунка the distributor (each 48 000 km (30 000 miles) run, or times in two years)
+ Рядный the six-cylinder engine
+ Engine V8
+ Procedure of the general and engine major repairs
+ Systems of cooling, heating and air conditioning
+ The power supply system and release of the fulfilled gases
+ System of an electric equipment of the engine
+ Systems of decrease in toxicity of the fulfilled gases and engine management
+ Manual box of a gear change
+ Automatic transmission
+ Distributing box
+ Coupling and трансмиссионная a line
+ Brake system
+ Suspension bracket and steering
+ Body
+ System of an onboard electric equipment
+ Controls and operation receptions

e65f60b7

Service of system of cooling (опорожнение, washing and refuelling) (each 48 000 km (30 000 miles) run, or times in two years)

Antifreeze is an aggressive and poisonous liquid, therefore it is necessary to avoid its hit on open sites of a body and the painted surfaces of the car. Casually got splashes immediately wash off a plentiful quantity of water. Do not leave a cooler spilt on a floor of garage or stored in open container - the sweetish smell of antifreeze can easily draw to itself attention of children and animals. Hit even insignificant quantity of a cooler in an organism is fraught with serious consequences, up to a lethal outcome. Before starting to cooler plum consult in dealer branch about rules of its recycling. In many regions special points on reception of poisonous working off of internal combustion engines are created.

In order to avoid development of corrosion and any formation of the adjournment influencing an overall performance of the engine and capable to become the reason of its damage to result of an overheat, it is necessary to make regularly опорожнение cooling systems, its washing and refuelling by a fresh mix. During service of system of cooling the condition of all its hoses and a radiator cover should be checked up. Replacement of defective components is in case of need made.

 PERFORMANCE ORDER

    Cock a lay brake and block wheel (wedges).

If the car was just used before to start to work wait for some hours necessary for cooling of the engine.

    Establish under the drain union of a radiator capacity of great volume for reception in it of a cooler. The drain stopper of a radiator on the models equipped with 6-cylinder engines is located in the right bottom part of a radiator, on models with engine V8 - at the left. If it is obviously possible, put on the drain union a hose in diameter about 10 mm for the most exact updating of a direction of a stream of a following liquid in drain capacity, then open the union gate (for its turn probably it is necessary to take advantage of flat-nose pliers). After full опорожнения a broad tank of system uncover a radiator, having provided plums of a liquid and from it. Then move capacity under a drain stopper of the block of the engine - on engine V8 from each party of the block is available on one such stopper, on the 6-cylinder engine the stopper is located on the right wall of the block. Remove a stopper allow to a cooler to flow down from the block.

Often the cooler does not start to follow from the block after stopper removal. Corking of a drain aperture by a rust the crosspiece from which is formed at once behind a stopper appears the reason of this phenomenon usually. Punch a crosspiece a screw-driver.


On 6-cylinder engines the drain stopper (arrow) is located on the left wall of the block, is direct under a final collector.

On engines V8 the block of cylinders is equipped by two drain stoppers - on one from each of the parties.

    While the cooler follows check up a condition радиаторных hoses, hoses of a heater and all шланговых collars (the Section Check of a condition and replacement of hoses passing under a cowl (each 4800 km (3000 miles) run or times in 3 months see)). Replace all damaged hoses and collars. After definitive опорожнения systems wash out a radiator fresh water from a garden hose. Washing continue until pure water will not start to follow from a radiator. The water stream will remove traces of adjournment from internal surfaces of a radiator, but cannot deduce from system products of corrosion and a scum. Last of the mentioned products are deduced by a chemical way by means of a special cleaner - follow instructions of manufacturers. In case of serious corrosion or damage of its radiator it is necessary to remove (the Head of System of cooling, heating and an air conditioning) and to send in special repair shop. Disconnect from a broad tank переливной a hose of a radiator and wash out a tank pure water, then connect a hose into place. Close and tighten the gate of the drain union of a radiator. Establish into place and tighten a drain stopper () the engine block. Translate the handle of management of heater operating modes in the maximum position. Slowly add in a radiator a fresh cooler (50 % a mix of antifreeze with water). A gulf continue before radiator filling. Add a cooler in a broad tank of system to its bottom label. Having left a cover of a radiator opened, start the engine (the car should be established in well ventilated premise or in the open air). Wait thermostat opening (the cooler will start to circulate on a radiator and the top hose of the last will get warm). Switch off the engine and allow to it to cool down. Add necessary quantity of a cooler for lifting of its level заподлицо with sponges of a jellied mouth of a radiator. Compress the top hose of a radiator, having expelled from it air, then, in case of need, add still a cooler. Establish into place a radiator cover. Start the engine, allow to it to get warm to normal working temperature and check up system on presence of leaks.